Modeling and Simulation of Magnetostrictive Impact Drive Mechanism

Abstract

Abstract: A model of magnetostrictive impact drive mechanism (IDM) was built to predict the step size and velocity, in which the dynamical model and the second order non-linear model of magnetostrictive material based on Jiles-Atherton model were considered. The simulation model was developed by utilizing MATLAB /Simulink software, and the data of IDM's displacement and velocity was obtained based on the model. The experimental system was built to testify the given model. The results illustrate that the error between experiment and simulation results are less than 15% within the range of driving current 0.2~0.4A and working frequency 10~100Hz. The proposed model can be used to predict the motion performance of magnetostrictive impact drive mechanism.

Key words: impact drive mechanism, magnetostrictive materials, non-linear model, dynamic model

CLC Number:

TM381

Zhao Ran, Lu Quanguo. Modeling and Simulation of Magnetostrictive Impact Drive Mechanism[J]. Journal of System Simulation, 2016, 28(7): 1547-1552.

References 18

[1]	Takeshi Morita, Takuma Nishimura, Ryuichi Yoshida, Hiroshi Hosaka.Design for the resonant type SIDM (Smooth Impact Drive Mechanism) actuator[J]. Proceedings of Symposium on Ultrasonic Electronics (S0021-14922), 2012, 33(11): 77-78.
[2]	Takuma Nishimura, Hiroshi Hosaka, Takeshi Morita.Resonant-type Smooth Impact Drive Mechanism (SIDM) actuator using a bolt-clamped Langevin transducer[J]. Ultrasonics (S0041-624X), 2012, 52(1): 75-80.
[3]	卢秋红, 高志军, 颜国正, 等. 压电型惯性微驱动器研究[J]. 压电与声光, 2004, 26(2): 112-115.
[4]	Won-jong Kim, Ali Sadighi. A Novel Low-Power Linear Magnetostrictive Actuator with Local Three-Phase Excitation[J]. IEEE/ASM Etransactions on Mechatronics (S1083-4435), 2010, 15(2): 299-307.
[5]	许文秉, 杨斌堂, 孟光, 等. 大负载精密驱动超磁致伸缩直线电机动力学建模与仿真[J]. 上海交通大学学报(自然科学版), 2012, 46(3): 480-486.
[6]	Jianjun Zhou, Yuliang Pan, Min Huang.A Novel Magnetostrictive Drive Rotary Motor[J]. Solid State Phenomena (S1662-9779), 2007, 121(3): 1203-1206.
[7]	Göran Engdahl.Handbook of Giant Magnetostrictive Materials [M]. San Diego, USA: Academic Press, 1999.
[8]	刘品宽, 孙立宁, 刘涛, 等. 惯性冲击式运动原理的理论分析与仿真[J]. 中国机械工程, 2015, 15(24): 2217-2221.
[9]	姜楠, 刘俊标. 惯性冲击马达的建模与仿真[J]. 系统仿真学报, 2009, 21(24): 7711-7714.
[10]	Chia-Feng Yang, Shyr-Long Jeng, Wei-Hua Chieng.Motion behavior of triangular waveform excitation input in an operating impact drive mechanism[J]. Sensors and Actuators A: Physical (S0734-2101), 2011, 166(12): 66-77.
[11]	G P Camran, M Miotrvie.Nonlinear Constitutive Relations for Magnetostrictive Materials with Application to l-D Problems[J]. J Intelligent Mat Syst. & Stm.(S1045-389X), 1995, 6(5): 673-684.
[12]	曹淑英. 超磁致伸缩驱动器的磁滞动态模型及控制技术 [D]. 天津: 河北工业大学, 2004.
[13]	S Karunanidhi, M Singaperumal.Design, analysis and simulation of magnetostrictive actuator and its application to high dynamic servo valve[J]. Sensors and Actuators A: Physics (S0734-2101), 2010, 157(2): 185-197.
[14]	卢全国. 基于GMM的微致动研究及应用 [D]. 武汉: 武汉理工大学, 2007.
[15]	Y F Liu, J Li, Z M Zhang, et al.Modeling and control of piezoelectric inertia-friction actuators: review and future research directions[J]. Mech. Sci.(S2191-9151), 2015, 6(2): 95-107.
[16]	卢全国, 陈定方,舒亮, 等.一种磁致伸缩式惯性冲击微型直线电机: 中国, ZL201010612116. 2 [P]. 2010.
[17]	卢全国, 赵冉, 曹清华. 磁致伸缩式惯性冲击电机驱动电源研究[J]. 电力电子技术, 2013, 47(8): 72-73.
[18]	赵冉, 卢全国. 基于Buck电路的超磁致惯性冲击电机电流滞环控制[J]. 微特电机, 2013, 41(12): 63-65.