倒伞形表面曝气搅拌槽内气液两相流的模拟研究

doi:10.16182/j.issn1004731x.joss.17-0139

系统仿真学报 ›› 2019, Vol. 31 ›› Issue (4): 696-701.doi: 10.16182/j.issn1004731x.joss.17-0139

倒伞形表面曝气搅拌槽内气液两相流的模拟研究

魏文礼, 娄威立, 李盼盼, 刘玉玲

西安理工大学水利水电学院,西安 710048

收稿日期:2017-03-23 修回日期:2017-09-25 出版日期:2019-04-08 发布日期:2019-11-20
作者简介:魏文礼(1965-),男,陕西大荔,博士,教授,研究方向为环境水力学、水污染控制理论与技术。
基金资助:
国家自然科学基金(51578452; 51178391),陕西省工业科技攻关项目(2016GY-180), 陕西省科学研究计划项目(2014K15-03-05)

Simulation of Gas-liquid Mixing Flow in a Stirred Tank with Inverted Umbrella-type Surface Aerator

Wei Wenli, Lou Weili, Li Panpan, Liu Yuling

Institute of Water Conservancy and Hydraulic Engineering, Xi'an University of Technology, Xi'an 710048, China

Received:2017-03-23 Revised:2017-09-25 Online:2019-04-08 Published:2019-11-20

摘要/Abstract

摘要： 运用CFD方法、RNG k-ε湍流模型以及多参考系法,在搅拌器内对单个表面曝气装置加以5.23 rad/s的角速度旋转的气液两相混合液的水力特性进行数值模拟计算,模拟的曝气装置是由八个叶片单元组成的倒伞形转轮装置,旨在分析和研究该表面曝气搅拌槽内的总体和局部含气率的分布特征以及流场特性。模拟结果表明：搅拌器内的流场呈对称分布,不同位置处的含气率在轴向上的变化规律几乎完全一致,在径向上的变化规律也保持很好的一致性、只有转轮所在区域处含气率沿径向的变化有细微差异。

关键词: 表面曝气, 气-液两相流, 含气率, 水力特性, 数值模拟

Abstract: The way of computational fluid dynamics with k-ε turbulence model as well as multiple reference frame method was used to simulate the hydraulic characteristics of gas-liquid mixing flow in a stirred tank installed with an inverted umbrella-type surface aerator. The inverted umbrella aerator consists of eight blades, and rotates at 5.23rad/s. The main purpose of this simulation is to study the distributions of air volume fraction and characteristics of mixing flow. The simulation results show that the distribution of the mixing flow is symmetrical; the change rules of the gas distribution at different positions along the axis direction are almost the same case and on radial direction keep in good consistency; and only in the region where the surface aerator is installed the gas distribution along the radius has some difference.

Key words: surface aerator, gas-liquid two-phase flow, air volume fraction, hydraulic characteristics, numerical simulation

中图分类号:

X131.2

魏文礼, 娄威立, 李盼盼, 刘玉玲. 倒伞形表面曝气搅拌槽内气液两相流的模拟研究[J]. 系统仿真学报, 2019, 31(4): 696-701.

Wei Wenli, Lou Weili, Li Panpan, Liu Yuling. Simulation of Gas-liquid Mixing Flow in a Stirred Tank with Inverted Umbrella-type Surface Aerator[J]. Journal of System Simulation, 2019, 31(4): 696-701.

参考文献

[1] 李向阳, 禹耕之, 毛在砂. 带气体分布器表面曝气反应器的气液传质特性[J]. 化学工程, 2007, 35(2): 30-33.
Li Xiangyang, Yu Gengzhi, Mao Zaisha.Gas dispersion and gas-liquid mass transfer in surface aerated stirred tanks with gas sparging[J]. Chemical Engineering, 2007, 35(2): 30-33.
[2] 周文忠, 范奎, 勾全增. 倒伞型表面曝气机充氧特性研究[J]. 工业用水与废水, 2013, 44(4): 58-60.
Zhou Wenzhong, Fan Kui, Gou Quanzeng.Study on oxygen transfer characteristics of inverted-umbrella type surface aerator[J]. Industrial Water & Wastewater, 2013, 44(4): 58-60.
[3] Taghavi M, Zadghaffari R, Moghaddas J, et al.Experimental and CFD investigation of power consumption in a dual Rushton turbine stirred tank[J]. Chemical Engineering Research and Design (S0263-8762), 2011, 89(3): 280-290.
[4] Gresch M, Armbruster M, Braun D, et al.Effects of aeration patterns on the flow field in wastewater aeration tanks[J]. Water research (S0043-1354), 2011, 45(2): 810-818.
[5] 潘哲, 汪家权, 范奎, 等. 几种倒伞型表面曝气机的充氧性能[J]. 环境工程学报, 2012, 6(6): 1936-1940.
Pan Zhe, Wang Jiaquan, Fan Kui, et al.Oxygenating properties of different inverted umbrella surface aerators[J]. Chinese Journal of Environmental Engineering, 2012, 6(6): 1936-1940.
[6] Busciglio A, Montante G, Paglianti A.Flow field and homogenization time assessment incontinuously-fed stirred tanks[J]. chemical engineering research and design (S0263-8762), 2015, 1(2): 42-56.
[7] Yoon H S, Balachandar S, Ha M Y.Large eddy simulation of passive scalar transport in a stirred tank for different diffusivities[J]. International Journal of Heat and Mass Transfer (S0017-9310), 2015, 91: 885-897.
[8] Stryjewski W S, Tabiś B, Boroń D.Dynamic behaviour of stirred tank bioreactors based on structured and unstructured kinetic models: A comparative study[J]. Chemical engineering research and design (S0263-8762) , 2015, 104: 541-550.
[9] Wang S Y, Jiang X X, Wang R C, et al.Numerical simulation of flow behavior of particles in a liquid-solid stirred vessel with baffles[J]. Advanced Powder Technology (S0921-8831), 2017, 28: 1611-1624.
[10] Pianko-Oprych P, Nienow A W, Barigou M.Positron emission particle tracking (PEPT) compared to particle image velocimetry (PIV) for studying the flow generated by a pitched-blade turbine in single phase and multi-phase systems[J]. Chem. Eng. Sci (S0009-2509), 2009, 64: 4955-4968.
[11] 魏文礼, 刘玉玲. 多相流模拟理论及其在污水处理工程中的应用[M]. 西安: 陕西科学技术出版社, 2015: 102-116.
Wei Wenli, Liu Yuling.Theory of multiphase flow simulation with applications in wastewater treatment engineering[M]. Xi'an: Shaanxi Science and Technology Press, 2015: 102-116.

[1]	岳奎志, 张原, 程亮亮, 郁大照. 基于CFD理论的双飞翼无人机气动特性数值模拟[J]. 系统仿真学报, 2021, 33(7): 1654-1660.
[2]	周春辉, 黄弘逊, 易晚霞, 陈立家, 文元桥, 谭林旭. 桥区河段原油船队航行仿真方法研究[J]. 系统仿真学报, 2021, 33(3): 690-697.
[3]	韩桂华, 刘亚楠, 邵俊鹏, 张此军. 文丘里管内空化演变模型研究[J]. 系统仿真学报, 2020, 32(2): 164-171.
[4]	王芹, 马召灿, 李鸿亮, 张林波, 卢本卓. 双极器件LPNP辐照损伤效应的并行有限元数值模拟[J]. 系统仿真学报, 2020, 32(12): 2376-2382.
[5]	林家泉, 孙凤山, 李亚冲. 客舱内呼吸道病原体传播与感染风险数值模拟[J]. 系统仿真学报, 2019, 31(8): 1541-1547.
[6]	皮骏, 高树伟, 黄江博, 黄磊, 马龙. 基于QAR数据的涡轮叶片疲劳寿命预测[J]. 系统仿真学报, 2019, 31(6): 1165-1171.
[7]	黄海波, 余旭东, 刘清国, 张涛, 董家楠. 汽车车轮周围气流场的数值模拟研究[J]. 系统仿真学报, 2019, 31(4): 641-647.
[8]	吴加权, 李红艳, 叶飞, 张馨予, 马琨. 预损伤钢筋混凝土梁有限元数值模拟研究[J]. 系统仿真学报, 2018, 30(9): 3437-3444.
[9]	李春曦, 张硕, 叶学民. 界面曲率对超疏水微通道减阻的影响[J]. 系统仿真学报, 2018, 30(6): 2405-2413.
[10]	王纪森, 贾倩, 陈晨, 张亚平, 杜疆. 液压管路油液流动的湍流模型参数修正研究[J]. 系统仿真学报, 2018, 30(5): 1665-1671.
[11]	马泽文, 刘涛, 孙旭东. 基于CFD的结晶搅拌反应釜流场分析与改进[J]. 系统仿真学报, 2018, 30(5): 1900-1907.
[12]	刘玲, 肖利萍, 李喜林. 铬渣渗滤液中六价铬在地下水中迁移模拟[J]. 系统仿真学报, 2018, 30(2): 560-568.
[13]	谭波, 刘宏杰, 苗润, 曾亮. 不同装药形式环形聚能战斗部侵彻性能研究[J]. 系统仿真学报, 2018, 30(12): 4808-4815.
[14]	李春曦, 薛全喜, 张硕, 叶学民. 微结构表面防微生物粘附机理研究[J]. 系统仿真学报, 2018, 30(10): 3903-3913.
[15]	刘延斌, 王亚威, 韩建海. 正负刚度并联的磁流变隔振器性能分析及优化[J]. 系统仿真学报, 2018, 30(10): 3965-3975.

倒伞形表面曝气搅拌槽内气液两相流的模拟研究

Simulation of Gas-liquid Mixing Flow in a Stirred Tank with Inverted Umbrella-type Surface Aerator

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价