不同开关表下PMSM直接转矩控制性能仿真研究

doi:10.16182/j.issn1004731x.joss.201811039

摘要/Abstract

摘要： 直接转矩控制(DTC)下永磁同步电动机(PMSM)运动系统中,逆变器输出电压矢量时会产生高频共模电压,DTC双闭环Bang-Bang控制结构也会造成电流谐波畸变与转矩的高频脉动。在Matlab/Simulink中建立其仿真模型,分别采用6矢量和7矢量开关表,并比较控制性能、电流、转矩和共模电压的变化,仿真结果表明两者动态性能相近,然而7矢量开关表控制相对于6矢量开关表而言,对电流谐波畸变以及转矩频谱中非基频分量都有所抑制,但同时增大了共模电压。该分析结果为逆变器在各种应用场合下控制输出方式的选择提供了参考依据。

关键词: 开关表, 永磁同步电动机, 直接转矩控制, 共模电压

Abstract: In the motion system of permanent magnet synchronous motor (PMSM) under direct torque control (DTC), the inverter produces high-frequency common-mode voltage (CMV) based on the switching table when outputting voltage vectors, and its double-closed-loop Bang-Bang control structure also causes current harmonic distortion and high-frequency ripple of the torque. A simulation model is established for PMSM motion system under DTC based on Matlab/Simulink using different switching tables, where performance and CMV between 7 vectors and 6 vectors switching tables are compared respectively. The results demonstrate that both have similar dynamic performance; relative to 6 vectors switching table, 7 vectors switching table suppresses current harmonic distortion and non-fundamental frequency of torque spectrum better, while the CMV increases at the same time. The analysis results can serve as a reference for the choice of actual inverter output mode.

Key words: switching tables, PMSM, DTC, Common-mode voltage

中图分类号:

TM351

罗浩源, 袁登科, 胡宗杰. 不同开关表下PMSM直接转矩控制性能仿真研究[J]. 系统仿真学报, 2018, 30(11): 4375-4386.

Luo Haoyuan, Yuan Dengke, Hu Zongjie. Simulation Study on Control Performance of PMSM-DTC under Different Switching Tables[J]. Journal of System Simulation, 2018, 30(11): 4375-4386.

参考文献

[1] 李潇. 永磁同步电机直接转矩控制的理论研究[D]. 贵阳: 贵州大学, 2007: 1-6.
Li Xiao.Theoretical Study on Direct Torque Control of PMSM [D]. Guiyang: Guizhou University, 2007: 1-6.
[2] 冯涛, 陆华. 永磁同步电机直接转矩控制及仿真[J]. 电机与控制应用, 2013, 40(6): 27-31.
Feng Tao, Lu Hua.Direct Torque Control and Simulation of Permanent Magnet Synchronous Motor[J]. Electric Machines & Control Application, 2013, 40(6): 27-31.
[3] 徐祖华, 黄智伟, 盛义发. 永磁同步电机直接转矩控制理论基础与仿真研究[J]. 微特电机, 2003, 31(5): 11.
Xu Zuhua, Huang Zhiwei, Sheng Yifa.Principle and Simulation Study on Direct Torque Control in Permanent Magnet Synchronous Motor[J]. Small & Special Electrical Machines, 2003, 31(5): 11.
[4] 姚海兰. 永磁同步电机直接转矩控制系统[D]. 上海: 同济大学, 2008:2-5.
Yao Hailan.Direct Torque Control System of Permanent Magnet Synchronous Motor [D]. Shanghai: Tongji University, 2008: 2-5.
[5] Giuseppe S Buja, Marian P Kazmierkowski.Direct Torque Control of PWM Inverter-Fed AC Motors-A Survey[J]. IEEE Transactions on Industrial Electronics (S0278-0046), 2004, 51(4): 754.
[6] 郎宝华, 刘卫国, 贺虎成. 基于空间矢量调制的PMSM直接转矩控制系统[J]. 系统仿真学报, 2009, 21(3): 836-840, 844.
Lang Baohua, Liu Weiguo, He Hucheng.Direct Torque Control System of PMSM Based on Space Vector Modulation[J]. Journal of System Simulation, 2009, 21(3): 836-840, 844.
[7] 张强, 韩如成, 李宁. PMSM-DTC与SVM-PMSM-DTC仿真对比[J]. 工业控制计算机, 2014, 27(1): 46-48.
Zhang Qiang, Han Rucheng, Li Ning.Comparison of PMSM-DTC Simulation and SVM-PMSM-DTC Simulation[J]. Industrial Control Computer, 2014, 27(1): 46-48.
[8] 李耀华, 马建, 刘晶郁, 等. 电动汽车用永磁同步电机直接转矩控制电压矢量选择策略[J]. 电机与控制学报, 2012, 16(4): 43-49.
Li Yaohua, Ma Jian, Liu Jingyu, et al.Voltage vector selection strategy of the DTC for PMSM used in electrical vehicle[J]. Electric Machines and Control, 2012, 16(4): 43-49.
[9] 吕帅帅, 林辉, 李兵强. 开关频率恒定与占空比调制相结合的PMSM-DTC控制[J]. 电工技术学报, 2016, 31(3): 72-80.
Lü Shuaishuai, Lin Hui, Li Bingqiang.Direct Torque Control Based on Simple Duty Ratio and Fixed Switching Frequency for PMSM[J]. Transactions of China ElectroTechnical Society, 2016, 31(3): 72-80.
[10] 孙丹, 何宗元, Ivonne Yznaga Blanco, 等. 四开关逆变器供电永磁同步电机直接转矩控制系统转矩脉动抑制[J]. 中国电机工程学报, 2007, 27(21): 47-52.
Sun Dan, He Zongyuan, Ivonne Yznaga Blanco, et al, Torque Ripple Reduction for a Four-switch Inverter Fed PMSM DTC System[J]. Proceedings of the CSEE, 2007, 27(21): 47-52.
[11] 李建超, 安群涛, 赵克, 等. 一种基于SVPWM的永磁同步电动机直接转矩控制系统仿真实验研究[J]. 微电机, 2008, 41(4): 9-11, 82.
Li Jianchao, An Quntao, Zhao Ke, et al.Modeling and Simulation of PMSM DTC System Using SVPWM[J]. Micromotor Servo Technique, 2008, 41(4): 9-11, 82.
[12] 陈殷, 孙丹, 林斌. 永磁同步电机无差拍直接转矩控制系统研究[J]. 机电工程, 2014, 31(8): 1053-1057.
Chen Yin, Sun Dan, Lin Bin.System of dead-beat direct torque control of permanent magnet synchronous motor[J]. Journal of Mechanical & Electrical Engineering, 2014, 31(8): 1053-1057.
[13] 高儒, 葛兴来. 基于间接定子量的永磁同步电动机三电平直接转矩控制[J]. 微特电机, 2015, 43(2): 39-43.
Gao Ru, Ge Xinglai.Indirect Stator-Quantities System of Three-Level Direct Torque Control for Permanent Magnet Synchronous Motors[J]. Diver and Control, 2015, 43(2): 39-43.
[14] 李耀华, 曲亚飞, 师浩浩, 等. 一种基于开关次数最小的含零电压矢量永磁同步电机直接转矩控制开关表[J]. 电机与控制应用, 2018, 45(2): 34-39.
Li Yaohua, Qu Yafei, Shi Haohao, et al.A Switching Table Based on Minimum Switching Times Using Zero Voltage Vectors in Permanent Magnet Synchronous Motor Direct Torque Control System[J]. Electric Machines & Control Application, 2018, 45(2): 34-39.
[15] 牛慧文, 王淑红, 侯胜伟, 等. 基于零电压矢量的永磁同步电机直接转矩控制系统[J]. 电气技术, 2012(7): 8-10+30.
Niu Huiwen, Wang Shuhong, Hou Shengwei, et al. The Direct Torque Control of PMSM Based on the Zero Voltage Space Vector [J]. Electrical Technology, 2012(7): 8-10+30.
[16] 曹林柏, 赵宏革, 张智远, 等. 基于十二电压矢量的电力推进PMSM直接转矩控制仿真[J]. 大连海事大学学报, 2015, 41(1): 100-103, 108.
Cao Linbo, Zhao Hongge, Zhang Zhiyuan, et al.Simulation of PMSM electric propulsion direct torque control with twelve voltage vectors[J]. Journal of Dalian Maritime University, 2015, 41(1): 100-103, 108.
[17] 李耀华, 郭巧娟, 吴俊, 等. 永磁同步电机直接转矩控制系统开关表分析[J]. 电气传动, 2012, 42(11): 15-17, 22.
Li Yaohua, Guo Qiaojuan, Wu Jun, et al.Analysis of the Switching Table of the PMSM DTC System[J]. Electrical Driver, 2012, 42(11): 15-17, 22.
[18] 李耀华, 刘卫国, 商蓓, 等. 一种减小永磁同步电机直接转矩控制系统转矩波动的开关表[J]. 微电机, 2009, 42(12): 42-46.
Li Yaohua, Liu Weiguo, Shang Bei, et al.A Switching Table to Decrease Torque Ripple for the PMSM DTC Drivers[J]. Micromotor Servo Technique, 2009, 42(12): 42-46.
[19] 樊明迪, 林辉, 吕帅帅. 一种抑制PMSM-DTC周期性转速脉动的方法[J]. 电机与控制学报, 2013, 17(9): 73-78, 85.
Fan Mingdi, Lin Hui, Lü Shuaishuai.Method to reduce periotic speed ripple in PMSM-DTC system[J]. Electric Machines and Control, 2013, 17(9): 73-78, 85.
[20] 姜艳姝, 陈勇. DTC技术对电机驱动系统中共模电压的抑制效果研究[J]. 黑龙江水专学报, 2009, 36(2):82-84.
Jiang Yanshu, Chen Yong.Study on Common-mode Voltage Reduction by Direct Torque Control in Motor Driving System[J]. Journal of Heilong Hydraulic Engineering, 2009, 36(2): 82-84.
[21] 戴珊,顾涛,杨磊,等. 逆变器输出端共模电压与差模电压dv/dt滤波器设计[J]. 电源技术, 2015, 39(9):1985-1988.
Dai Shan, Gu Tao, Yang Lei, et al.Design of common-mode and differential-mode voltage dv/dt filter at inverter output terminals[J], Chinese Journal of Power Sources, 2015, 39(9): 1985-1988.
[22] 刘建强, 郑琼林. 各种PWM控制方式下的电机共模电压比较研究[J]. 北京交通大学学报, 2005, 29(5): 98-102.
Liu Jianqiang, Zheng Qionglin.Study and Comparison of the Common-Mode Motor Voltage in Different Kinds of PWM Control Methods[J]. Journal of Beijing Jiaotong University, 2005, 29(5): 98-102.
[23] 田淳, 胡育文. 永磁同步电机直接转矩控制系统理论及控制方案的研究[J]. 电工技术学报, 2002, 17(1): 7-11.
Tian Chun, Hu Yuwen.Study of the Scheme and Theory of the Direct Torque Control in Permanent Magnet Synchronous Motor Drivers[J]. Transactions of China ElectroTechnical Society, 2002, 17(1): 7-11.
[24] 袁登科, 徐延东, 李秀涛, 等. 永磁同步电动机变频调速系统及其控制[M]. 北京: 机械工业出版社, 2015: 294-306.
Yuan Dengke, Xü Yandong, Li Xiutao, et al.Variable Frequency Speed Control System and Its Control of PMSM [M]. Beijing: China Machine Press, 2015: 294-306.
[25] Sikyung Kim, P N Enjeti, I J Pitel. A new approach to improve power factor and reduce harmonics in three phase diode rectifier type utility interface[J]. IEEE Transactions on Industrial Applications (S0093-9994), 1994, 30(11): 1557-1564.
[26] 杨建飞. 永磁同步电机直接转矩控制系统若干关键问题研究[D]. 南京: 南京航空航天大学, 2011: 3-10.
Yang Jianfei.Research on Some Key Problems of Direct Torque Control on Permanent Magnet Synchronous Motor [D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2011: 3-10.
[27] 李耀华, 刘卫国. 零电压矢量在PMSM直接转矩控制系统中的应用[J]. 电力电子技术, 2010, 44(9): 50-51,62.
Li Yaohua, Liu Weiguo.Study of the Use of Zero Voltage Vectors in the PMSM DTC System[J]. Power Electronics, 2010, 44(9): 50-51, 62.
[28] Revision of IEEE Std1459-2010, 2010. IEEE Standard Definition for the Measurement of Electric Power Quantities Under Sinusoidal, Nonsinusoidal, Balance, or Unbalance Condition[S](Sponsored by the Power System Instrumentation and Measurements Committee).