电站锅炉烟气余热及水分回收系统仿真研究

doi:10.16182/j.issn1004731x.joss.201707021

系统仿真学报 ›› 2017, Vol. 29 ›› Issue (7): 1553-1560.doi: 10.16182/j.issn1004731x.joss.201707021

电站锅炉烟气余热及水分回收系统仿真研究

王金平, 邓煜, 李斌, 朱瑞

华北电力大学能源动力与机械工程学院,河北保定 071003

收稿日期:2016-03-28 发布日期:2020-06-01
通讯作者: 邓煜(1992-),男,湖南永州,硕士生,研究方向为烟气余热回收及仿真系统。
作者简介:王金平(1975-),男,山东德州,博士生,研究方向为烟气余热利用建模与仿真及热力系统性能分析等。
基金资助:
国家科技支撑计划(2010BAA07B01)

Simulation on Waste Heat and Water Recovery System of Flue Gas in Plant Boiler

Wang Jinping, Deng Yu, Li Bin, Zhu Rui

School of Energy Power and Mechanical Engineering, North China Electric Power University, Baoding 071003, China

Received:2016-03-28 Published:2020-06-01

摘要/Abstract

摘要： 为了进一步提高电厂经济性,提出了锅炉烟气余热及水分回收系统。建立了烟气冷却器的数学模型,同时构建了烟气余热及水分回收系统的仿真模型,并将其集成到该机组的仿真系统中并对该系统进行仿真实验,分析了系统的投入对火电机组运行特性的影响。通过阀门扰动实验,研究了余热及水分回收系统的动态特性。结果表明,系统的投入不仅能提高机组经济性,还能够有效的回收烟气中的水分,同时对火电机组运行的稳定性影响不大,在机组原DCS控制系统的调节下,机组能稳定运行。

关键词: 余热利用, 水分回收, 烟气冷却器, 动态特性

Abstract: To further improve economy of power plant, the waste heat and water recovery system was put forward. The mathematical model of the gas cooler was established, and the simulation model of this system was built. This simulation model was integrated into the simulation system of a 350mw heating unit, and the simulation experiment was carried out. The influences caused by the introduction of the flue gas waste heat and water recovery system to thermal power unit were analyzed. The dynamic characteristics of the flue gas waste heat and water recovery system based on the valve perturbation experiments were studied. The results indicate that the introduction of the flue gas waste heat and water recovery system can not only improve the economy of the unit, but also can effectively recover the moisture in the flue gas. Besides, it has little effect on the operation stability of the thermal power unit, and the stable operation of this unit by the regulation of DCS control system can be realized.

Key words: flue gas waste heat utilization, moisture recovery, flue cooler, mdynamic characteristic

中图分类号:

TK01+9

王金平, 邓煜, 李斌, 朱瑞. 电站锅炉烟气余热及水分回收系统仿真研究[J]. 系统仿真学报, 2017, 29(7): 1553-1560.

Wang Jinping, Deng Yu, Li Bin, Zhu Rui. Simulation on Waste Heat and Water Recovery System of Flue Gas in Plant Boiler[J]. Journal of System Simulation, 2017, 29(7): 1553-1560.

参考文献

[1] 张方炜. 锅炉烟气余热利用研究[J]. 电力勘测设计, 2010(4): 48-52, 75.(Fangwei Zhang. Application of exhaust gas surplus heat of boiler [J]. Electric Power Survey and Design, 2010 (4): 48-52, 75.)
[2] 谭青, 王东平, 王伟敏, 等. 锅炉烟气余热回收装置[J]. 上海节能, 2012, 31(5): 30-33, 36.(Qing Tan, Dongping Wang, Weimin Wang, et al. Boiler flue gas waste heat recovery unit [J]. Shanghai Energy Conservation, 2012, 31(5): 30-33, 36.)
[3] 韩宇, 徐钢, 杨勇平, 等. 燃煤电站清洁高效协同的烟气余热深度利用优化系统[J]. 动力工程学报, 2015, 35(8): 674-680.
(Yu Han, Gang Xu, Yongping Yang.An optimized system for clean, efficient and deep utilization of flue gas waste heat from coal-fired power plants[J]. Journal of Chinese Society of Power Engineering, 2015, 35(8): 674-680.)
[4] Electric Power Research Institute. Retrofits for improved heat rate and availability (low-level heat recovery economizer retrofits) [R]. Reading: Electric Power Research Institute, 1992.
[5] 徐钢, 许诚, 杨勇平, 等. 电站锅炉余热深度利用及尾部受热面综合优化[J]. 中国电机工程学报, 2013, 33(14): 1-8.
(Gang Xu, Cheng Xu, Yongping Yang, et al.Deep utilization of exhaust heat and comprehensive optimization of tail heating surfaces for utility boilers[J]. Proceedings of the CSEE, 2013, 33(14): 1-8.)
[6] 程远. 四机组烟机余热发电装置的建模与仿真[J]. 系统仿真学报, 1996(2): 32-39.
(Yuan Chen.Modelling and simulation of flue gas waste heat generator[J]. Journal of System Simulation (S1004-731X), 1996(2): 32-39.)
[7] 裘浔隽, 杨瑜文. 余热锅炉的动态数学模型及数字仿真[J]. 动力工程学报, 2002, 22(6): 2078-2083.
(Xunjun Qiu, Yuwen Yang.Numerical model and simulation of the heat recovery steam generator[J]. Journal of Chinese Society of Power Engineering, 2002, 22(6): 2078-2083.)
[8] 马文通, 王岳人. 自然循环余热锅炉动态仿真研究[J]. 系统仿真学报, 2007, 19(17): 4055-4060.
(Wentong Ma, Yueren Wang.Dynamic simulation of natural circulation HRSG[J]. Journal of System Simulation (S1004-731X), 2007, 19(17): 4055-4060.)
[9] 涂鸣, 李刚炎, 胡剑. 不同工况柴油机排气余热回收系统试验与仿真[J]. 农业机械学报, 2014, 45(2): 1-5.
(Ming Tu, Gangyan Li, Jian Hu.Experiment and simulation of diesel engine exhaust heat recovery system under variable conditions[J]. Transactions of The Chinese Society of Agricultural Machinery, 2014, 45(2): 1-5.)
[10] 于雷, 王少明. 核动力装置非能动余热排出系统的数学建模与仿真[J]. 系统仿真学报, 2009, 21(7): 1845-1850.
(Lei Yu, Shaoming Wang.Modeling and simulation of passive residual heat removal system in nuclear power plant[J]. Journal of System Simulation (S1004-731X), 2009, 21(7): 1845-1850.)
[11] 赵辉, 王亚菲, 李克卿, 等. 余热发电机组电能稳定性控制仿真研究[J]. 计算机仿真, 2015, 32(7): 92-95.
(Hui Zhao, Yafei Wang, Keqin Li.Simulation study on waste heat power generators power stability control[J]. Computer Simulation, 2015, 32(7): 92-95.)
[12] 崔凝, 王兵树, 高建强, 等. 大容量余热锅炉动态模型的研究与应用[J]. 中国电机工程学报, 2006, 26(19): 103-109.
(Ning Cui, Bingshu Wang, JianQiang Gao, etc. Research and application of dynamic model of large capacity waste heat boiler[J]. Proceedings of the CSEE, 2006, 26(19): 103-109. )

电站锅炉烟气余热及水分回收系统仿真研究

Simulation on Waste Heat and Water Recovery System of Flue Gas in Plant Boiler

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价

[1]	刘欣荣, 汪中厚, 久保爱三, 张开元. 基于ABAQUS的渐开线斜齿圆柱齿轮传动误差研究[J]. 系统仿真学报, 2018, 30(10): 4002-4009.
[2]	高建强, 孙少东. 300 MW褐煤富氧燃烧锅炉制粉系统仿真模型的研究[J]. 系统仿真学报, 2017, 29(2): 437-444.
[3]	韩璞, 张婷. 有机朗肯循环余热利用系统的多模型预测控制[J]. 系统仿真学报, 2017, 29(11): 2811-2819.
[4]	高建强, 张晨. 富氧燃煤锅炉烟气压缩系统动态特性分析[J]. 系统仿真学报, 2017, 29(10): 2528-2537.