动态热源的车载有机朗肯循环系统特性分析

系统仿真学报 ›› 2016, Vol. 28 ›› Issue (1): 1-7.

• 仿真建模理论与方法 • 下一篇

动态热源的车载有机朗肯循环系统特性分析

赵力, 黄炜

天津大学中低温热能高效利用教育部重点实验室,天津 300072

收稿日期:2014-07-24 修回日期:2014-10-17 发布日期:2020-07-02
作者简介:赵力(1972-),男,河北,博士,教授,研究方向为太阳能高效热利用、新型制冷剂的循环性能、制冷热泵系统的优化、仿真及控制、新型节能技术。
基金资助:
国家科技部863项目(2012AA051103); 天津市科技支撑重大项目(11ZCZDGZ19800)

Respond Performance to Dynamic Heat Resource of Organic Rankine Cycle for Waste Heat Recovery on Vehicle

Zhao Li, Huang Wei

Key Laboratory of Efficient Utilization of Low and Medium Grade Energy, Tianjin University, MOE, Tianjin 300072, China

Received:2014-07-24 Revised:2014-10-17 Published:2020-07-02

摘要/Abstract

摘要： 复杂路况造成汽车尾气参数呈现较强的动态特征,故有机朗肯循环(ORC, Organic Rankine Cycle)系统在尾气余热回收实际运行中往往偏离稳态设计工况点,造成实际效率偏低。针对此问题,建立了ORC系统动态模型,将热源动态特征分解为6种模式,分析了热源温度和流量阶跃对系统稳定性的影响。基于模拟结果的分析显示阶跃时间与系统稳定时间呈线性正相关;阶跃起始流量与系统稳定时间呈线性负相关;阶跃起始温度、阶跃温度变化值和流量变化值三者与稳定时间呈二次函数关系。相关研究结论对车载ORC系统控制设计有较好的指导意义。

关键词: 尾气, 余热回收, 朗肯循环, 动态模拟

Abstract: Complex traffic leads to a dynamic behavior of exhaust gas of vehicle. Therefore, a real operating of Organic Rankine Cycle (ORC), which is used for heat recovery, deviates the design working condition at most of time with a low operating efficiency. To solve the problem, a dynamic model of ORC system verified by experiment result was built. The dynamic behavior of the heat resource, divided into 6 modes, was used as an input of external condition to the developed model. The impact results of the step mass flow rate and the temperature of heat resource to the stability of system were analyzed. The results show that step time is appropriately positive linear to stable time. The initial mass flow rate is negative correlate to the stable time. The stable time is the quadric function of initial temperature, step span of temperature and mass flow rate. The research results show a useful meaning to understanding the dynamic behavior of ORC on vehicle and developing of control strategy.

Key words: exhaust, waste heat recovery, Rankine Cycle, dynamic simulation

中图分类号:

TK421⁺5

赵力, 黄炜. 动态热源的车载有机朗肯循环系统特性分析[J]. 系统仿真学报, 2016, 28(1): 1-7.

Zhao Li, Huang Wei. Respond Performance to Dynamic Heat Resource of Organic Rankine Cycle for Waste Heat Recovery on Vehicle[J]. Journal of System Simulation, 2016, 28(1): 1-7.

参考文献

[1] Wang T, Zhang Y, Peng Z, et al.A review of researches on thermal exhaust heat recovery with Rankine cycle[J]. Renewable and Sustainable Energy Reviews (S1364-0321), 2011, 15(6): 2862-2871.
[2] Teng H, Regner G, Cowland C. Achieving high engine efficiency for heavy-duty diesel engines by waste heat recovery using supercritical organic-fluid Rankine cycle [J]. Training, 2006-01-3522, 2006.
[3] 赵智博. 内燃机废气余热利用有机朗肯循环系统工质的分析研究[D]. 天津: 天津大学, 2012: 58-60.
[4] Wang E H, Zhang H G, Zhao Y, et al.Performance analysis of a novel system combining a dual loop organic Rankine cycle (ORC) with a gasoline engine[J]. Energy (S1998-4316), 2012, 43(1): 385-395.
[5] 方金莉, 魏名山, 王瑞君, 等. 采用中温有机朗肯循环回收重型柴油机排气余热的模拟[J]. 内燃机学报, 2010 (4): 362-367.
[6] 魏东红, 鲁雪生, 顾建明, 等. 移动边界模型应用于废热驱动的有机朗肯循环系统的动态仿真[J]. 上海交通大学学报, 2006 (8): 1394-1397.
[7] Xie H, Yang C.Dynamic behavior of Rankine cycle system for waste heat recovery of heavy duty diesel engines under driving cycle[J]. Applied Energy (S0306-2619), 2013(112): 130-141.
[8] Vaja I.Definition of an object oriented library for the dynamic simulation of advanced energy systems: methodologies, tools and application to combined ICE-ORC power plants [D]. Italia: Dipartimento di Ingegneria Industriale, Università di Parma, 2009: 70-78.
[9] 杨世铭, 陶文铨. 传热学[M]. 4版. 北京: 高等教育出版社, 2006: 209-248.
[10] Zhang S, Wang H, Guo T.Performance comparison and parametric optimization of subcritical Organic Rankine Cycle (ORC) and transcritical power cycle system for low-temperature geothermal power generation[J]. Applied Energy (S0306-2619), 2011, 88(8): 2740-2754.
[11] Ringler J, Seifert M, Guyotot V, et al.Rankine cycle for waste heat recovery of IC engines[J]. SAE International Journal of Engines 2009-01-0174, 2009, 2(1): 67-76.

动态热源的车载有机朗肯循环系统特性分析

Respond Performance to Dynamic Heat Resource of Organic Rankine Cycle for Waste Heat Recovery on Vehicle

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

编辑推荐

Metrics

本文评价

[1]	韩璞, 张婷. 有机朗肯循环余热利用系统的多模型预测控制[J]. 系统仿真学报, 2017, 29(11): 2811-2819.
[2]	肖艳军, 刘玉香, 王大源, 冯华, 李春霞. 罗茨式动力机的三维流场数值模拟与试验研究[J]. 系统仿真学报, 2015, 27(12): 2998-3005.
[3]	邢华桥, 侯妙乐, 王磊, 姜晓轶. 基于球面QTM的海平面上升淹没模拟系统[J]. 系统仿真学报, 2015, 27(11): 2689-2694.