三电平逆变器多故障模式识别方法

doi:10.16182/j.issn1004731x.joss.201707008

系统仿真学报 ›› 2017, Vol. 29 ›› Issue (7): 1447-1457.doi: 10.16182/j.issn1004731x.joss.201707008

三电平逆变器多故障模式识别方法

沈艳霞, 吴娟, 赵芝璞, 纪志成

江南大学物联网工程学院电气自动化研究所,江苏无锡 214122

收稿日期:2015-09-07 发布日期:2020-06-01
作者简介:沈艳霞(1973-),女,山东淄博,博士,教授,博导,研究方向为新能源控制技术、轻工装备智能制造。
基金资助:
国家自然科学基金(61573167),高等学校博士学科点专项科研基金(20130093110011),江苏省自然科学基金(BK20141114)

Multiple Faults Identification of Three-level Inverter

Shen Yanxia, Wu Juan, Zhao Zhipu, Ji Zhicheng

Institute of Electrical Automation, College of Internet of things Engineering, Jiangnan University, Wuxi 214122, China

Received:2015-09-07 Published:2020-06-01

摘要/Abstract

摘要： 以二极管中点钳位型三电平逆变器为例,分析了三电平逆变器单管开路和多管同时开路故障状态下的相电流和桥臂电压信号,提出了基于相空间重构和小波包分析的三电平逆变器故障识别方法。利用相空间重构技术,对相电流进行重构,得到表征系统故障特征的不同形状、大小和方向的电流轨迹图形,借助图像处理技术识别出相电流不同的各类故障;对相电流相同的不同故障模式辅以小波包分析,提取出桥臂电压的特征频谱,识别出三电平逆变器的所有典型故障。仿真与实验结果表明该方法可以精确提取出各故障状态的特征向量,实现多种故障模式的识别。

关键词: 三电平逆变器, 故障识别, 相电流, 桥臂电压, 相空间重构, 小波包分析

Abstract: A three-level neutral point clamped (NPC) inverter was taken as an example, phase current and bridge voltage in the fault states of single switch open and several switches open at the same time were analyzed, and a method based on reconstructive phase space (RPS) and wavelet packet analysis was proposed to identify three-level inverter faults. Based on RPS method, totally different reconstructed current trajectories were obtained, which showed the features of the inverter under different fault conditions. With the help of image processing technology, all kinds of faults with different phase currents were identified. The wavelet packet analysis was adopted to extract the features of frequency-spectrum for different faults with the same phase currents and all typical faults were identified. Simulations and experiments show that the method can accurately extract the feature vectors for each fault condition and various failure modes can be identified.

Key words: three-level inverter, fault identification, phase current, bridge voltage, reconstructive phase space, wavelet packet analysis

中图分类号:

TM464

沈艳霞, 吴娟, 赵芝璞, 纪志成. 三电平逆变器多故障模式识别方法[J]. 系统仿真学报, 2017, 29(7): 1447-1457.

Shen Yanxia, Wu Juan, Zhao Zhipu, Ji Zhicheng. Multiple Faults Identification of Three-level Inverter[J]. Journal of System Simulation, 2017, 29(7): 1447-1457.

参考文献

[1] Karimi S, Gaillard A, Poure P, et al.FPGA-based real-time power converter failure diagnosis for wind energy conversion systems[J]. IEEE Transactions on Industrial Electronics (S1557-9948), 2008, 55(12): 4299-4308.
[2] 汤清泉, 颜世超, 卢松升, 等. 三电平逆变器的功率管开路故障诊断[J]. 中国电机工程学报, 2008, 28(21): 26-32.
(Tang Qingquan, Yan Shichao, Lu Songsheng, et al.Open- circuit Fault Diagnosis of Transistor in Three-level Inverter[J]. Proceedings of the CSEE, 2008, 28(21): 26-32.)
[3] Ceballos S, Pou J, Robles E, et al.Three-leg fault-tolerant neutral-point-clamped converter[C]// IEEE International Symposium on Industrial Electronics, Vigo, Spain, USA: IEEE, 2007: 3180-3185.
[4] Tae-Jin Kim, Woo-Cheol Lee, Dong-Seok Hyun.Detection method for open-circuit fault in neutral-point-clamped inverter systems[J]. IEEE Transactions on Industrial Electronics (S1557-9948), 2009, 56(7): 2754-2763.
[5] Ui-Min Choi, Hae-Gwang Jeong, Kyo-Beum Lee, et al.Method for detecting an open-switch fault in a grid-connected NPC inverter system[J]. IEEE Transactions on Power Electronics (S1557-9948), 2012, 27(6): 2726-2739.
[6] Mohsen Bandar Abadi, Mendes A M S, Cruz S M A. Three-level NPC inverter fault diagnosis by the average current Park's vector approach[C]// IEEE International Conference on Electrical Machines (ICEM). Marseille, France, USA: IEEE, 2012: 1893-1898.
[7] June-Seok Lee, Kyo-Beum Lee, Blaabjerg F.Open-switch fault detection method of an NPC converter for wind turbine systems[C]// IEEE Energy Conversion Congress and Exposition (ECCE). Denver, CO, USA, USA, IEEE, 2013: 1696-1701.
[8] 陈丹江, 叶银忠, 华容. 基于波形实时分析的动车组三电平逆变器故障诊断技术[J]. 电工技术学报, 2014, 29(6): 106-113.
(Chen Danjiang, Ye Yinzhong, Hua Rong.Fault Diag- nosis for Three-Level Inverter of CRH Based on Real- Time Waveform Analysis[J]. Transactions of China Electrotechnical Society, 2014, 29(6): 106-113.
[9] 陈丹江,叶银忠. 基于多神经网络的三电平逆变器器件开路故障诊断方法[J]. 电工技术学报, 2013, 28(6): 120-126.
(Chen Danjiang, Ye Yinzhong.Fault Diagnosis of Three Level Inverter Based on Multi Neural Network[J]. Transactions of China Electrotechnical Society, 2013, 28(6): 120-126.)
[10] Bangun J, Povinelli R, Herdash N, et al.Diagnostics of eccentricities and bar/end-ring connector breakages in polyphase induction motors through a combination of time-series data mining and time stepping coupled- state-space techniques[J]. IEEE Transactions on Industry Applications (S1939-9367), 2003, 39(4): 1005-1013.
[11] 孙丹, 孟濬, 管宇凡. 基于相空间重构和模糊聚类的永磁同步电机直接转矩控制系统逆变器故障诊断[J]. 中国电机工程学报, 2007, 27(6): 49-53.
(Sun Dan, Meng Jun, Guan Yufan.Inverter Faults Diagnosis in PMSM DTC Drive Using Reconstructive Phase Space and Fuzzy Clustering[J]. Proceedings of the CSEE, 2007, 27(6): 49-53.
[12] 高俊杰. 混沌时间序列预测研究及应用 [D]. 上海: 上海交通大学, 2013: 15-20.
(Gao Junjie.Study and Application of Chaotic Time Series Prediction [D]. Shanghai, China: Shanghai Jiaotong University, 2013: 15-20.)
[13] Packard N H, Crutchfield J P, Farmer J D, et al.Geometry from a Time Series[J]. Physical Review Letters (S1079-7114), 1980, 45(9): 712-716.
[14] Takens F.Dynamical Systems and Turbulence: Detecting strange attractors in turbulence[M]. Warwick, UK: Springer, 1981: 366-381.

三电平逆变器多故障模式识别方法

Multiple Faults Identification of Three-level Inverter

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 7

编辑推荐

Metrics

本文评价

[1]	沈艳霞, 苗贝贝. 三电平逆变器的开关管开路故障诊断策略[J]. 系统仿真学报, 2018, 30(8): 3058-3065.
[2]	王丽婕, 张利, 张岩. 基于CEEMD和混沌理论的超短期风电功率预测模型[J]. 系统仿真学报, 2018, 30(4): 1560-1565.
[3]	马帅旗, 张鹏超. 非对称坐标系下SVPWM调制算法[J]. 系统仿真学报, 2017, 29(6): 1218-1222.
[4]	孟力, 毕叶平. 相空间重构文献综述可视化分析[J]. 系统仿真学报, 2017, 29(12): 3167-3175.
[5]	张宏立, 李瑞国, 范文慧. 基于相空间重构的Bernstein神经网络混沌序列预测[J]. 系统仿真学报, 2016, 28(4): 880-889.
[6]	夏飞, 郝硕涛, 张浩, 彭道刚. 改进粒子滤波和小波包在汽轮机振动诊断中的应用[J]. 系统仿真学报, 2016, 28(11): 2823-2831.
[7]	夏鲲, 李肖迪, 丁晓波, 曾彦能, 王一鸣, 许颇. 一种三电平逆变器中点电位控制方法仿真研究[J]. 系统仿真学报, 2016, 28(1): 235-241.