分体式开关磁阻双转子电机设计与电磁仿真

doi:10.16182/j.issn1004731x.joss.19-0642

系统仿真学报 ›› 2021, Vol. 33 ›› Issue (4): 935-942.doi: 10.16182/j.issn1004731x.joss.19-0642

分体式开关磁阻双转子电机设计与电磁仿真

邓涛¹, 邓凇²

1.重庆交通大学航空学院,重庆 400074;
2.重庆交通大学机电与车辆工程学院,重庆 400074

收稿日期:2019-12-09 修回日期:2020-02-03 出版日期:2021-04-18 发布日期:2021-04-14
作者简介:邓涛(1982-),男,博士,教授,研究方向为新能源汽车理论与应用。E-mail：d82t722@cqjtu.edu.cn
基金资助:
国家自然科学基金(51305473); 重庆市技术创新与应用发展专项重点项目(cstc2019jscx-fxydX0028); 重庆市教育委员会科学技术研究重点项目(KJZD-K202000701)

Design and Electromagnetic Simulation of Split Switched Reluctance Dual-Rotor Motor

Deng Tao¹, Deng Song²

1. Institute of Aeronautics, Chongqing Jiaotong University, Chongqing 400074, China;
2. School of Mechatronics & Automobile Engineering, Chongqing Jiaotong University, Chongqing 400074, China

Received:2019-12-09 Revised:2020-02-03 Online:2021-04-18 Published:2021-04-14

摘要/Abstract

摘要： 为解决传统混合动力汽车用双转子电机同心永磁式结构存在散热不良和磁场耦合等问题,将两个同尺寸开关磁阻电机通过联轴器机械连接起来,设计成一种新型分体式开关磁阻双转子电机(Split Switched Reluctance Dual-rotor Motor,SSR-DRM),分析其工作原理和多工况运行模式,进行参数设计、建模以及电磁静态和瞬态仿真,从磁力线分布、磁密、瞬态转矩与空载反电势等对比分析设计和仿真。结果表明：SSR-DRM的主、副电机在560 V直流电压下,额定转矩为80 N·m,额定转速为3 000 r/min,额定输出功率为25 kW,满足设计要求。

关键词: 分体式开关磁阻双转子电机, 结构设计, 参数设计, 电磁仿真

Abstract: There are some problems such as bad heat dissipation and electromagnetic coupling for the traditional dual-rotor motor of hybrid electric vehicles. Two SRMs of same size are mechanically connected through a coupling to form a dual-rotor motor with two rotors and one stator. A split switched reluctance dual-rotor motor (SSR-DRM) is innovatively designed. The working principle and multi-operating mode of SSR-DRM are analyzed, and the parameters design, modeling and electromagnetic simulation are implemented. The parameters of design and simulation are compared and analyzed from the aspects of magnetic line distribution, magnetic density, transient torque and no-load back EMF. The results show that under 560 V DC voltage, the split switched reluctance dual-rotor motor's rated torque is 80 N·m, rated speed is 3 000 r/min and rated output power is 25 kW. Simulation results meet the requirement of design.

Key words: split switched reluctance dual-rotor motor, structure design, parameter design, electromagnetic simulation

中图分类号:

TM35
TP391

邓涛, 邓凇. 分体式开关磁阻双转子电机设计与电磁仿真[J]. 系统仿真学报, 2021, 33(4): 935-942.

Deng Tao, Deng Song. Design and Electromagnetic Simulation of Split Switched Reluctance Dual-Rotor Motor[J]. Journal of System Simulation, 2021, 33(4): 935-942.

参考文献

[1] Hoeijmakers M J, Ferreira J A.The Electric Variable Transmission[J]. IEEE Trans. Ind. Appl.(S0278-0046), 2006, 42(4): 1092-1100.
[2] Abdollahi M, Mirsalim M.Novel E-Core Double-Stator Two Phase Switched Reluctance Motor with Segmental Rotor[C]//2019 10^th International Power Electronics, Drive Systems and Technologies Conference (PEDSTC), Shiraz, Iran, 12-14 February, 2019.
[3] Li Y J.Design and Optimization of a Novel Dual-Rotor Hybrid PM Machine for Traction Application[J]. IEEE Trans. Ind. Electron.(S0278-0046), 2018, 65(2): 1762-1771.
[4] Joachim D, Hendrik V.Torque Analysis on a Double Rotor Electrical Variable Transmission with Hybrid Excitation[J]. IEEE Trans. Ind. Electron.(S0278-0046), 2017, 64(1): 60-68.
[5] 庄兴明, 宋强, 温旭辉, 等. 辐型磁钢双机械端口电机的解耦控制[J]. 中国电机工程学报, 2014, 34(33): 5925-5933.
Zhuang Xingming, Song Qiang, Wen Xuhui, et al.Decoupling Control of Dual Mechanical Ports Machine with Spoke Type Permanent-magnet Arrangement[J]. Chinese Journal of Electrical Engineering, 2014, 34(33): 5925-5933.
[6] 高起兴, 王冲, 井立兵, 等. Halbach阵列双转子永磁电机磁场分析与转矩计算[J]. 微特电机, 2018, 46(11): 51-54.
Gao Qixing, Wang Chong, Jing Libing, et al.Magnetic Field Analysis and Torque Calculation of Dual-Rotor Permanent Magnet Motor with Halbach Array[J]. Micro-Special Motor, 2018, 46(11): 51-54.
[7] 陈云云, 朱孝勇, 全力, 等. 基于参数敏感度的双凸极永磁型双定子电机的优化设计和性能分析[J]. 电工技术学报, 2017, 32(8): 160-168.
Chen Yunyun, Zhu Xiaoyong, Quan Li, et al.Optimum Design and Performance Analysis of Doubly Salient Permanent Magnet Double Stator Motor based on Parameter Sensitivity[J]. Journal of Electrical Technology, 2017, 32(8): 160-168.
[8] 徐奇伟, 孙静, 赵蒙, 等. 混合动力车用电气无级变速器的电磁解耦优化设计[J]. 电工技术学报, 2018, 33(9): 2005-2014.
Xu Qiwei, Sun Jing, Zhao Meng, et al.Electromagnetic Decoupling Optimal Design of Electric Variable Transmission Used for Hybrid Electric Vehicle[J]. Journal of Electrical Technology, 2018, 33(9): 2005-2014.
[9] 韩守亮. 用于传动系统的开关磁阻式双转子电机的基础研究[D]. 哈尔滨: 哈尔滨工业大学, 2007.
Han Shouliang.The Basic Research of Switched Reluctance Double-rotor Applied to Transmission System[D]. Harbin: Harbin Institute of Technology, 2007.
[10] 陈云云. 混合动力汽车用双凸极式永磁双转子电机的研究[D]. 镇江: 江苏大学, 2014.
Chen Yunyun.Research on a Doubly-Salient Permanent- magnet Double-rotor Motor Applied for Hybrid Electric Vehicles[D]. Zhenjiang: Jiangsu University, 2014.
[11] 陈星, 苑士华, 胡纪滨, 等. 采用分体式双转子电机的混合动力系统的控制[J]. 华南理工大学学报, 2012, 40(7): 95-100.
Chen Xing, Yuan Shihua, Hu Jibin, et al.Control of Hybrid Power System with Split Dual-rotor Motor[J]. Journal of South China University of Technology, 2012, 40(7): 95-100.
[12] 吴红星. 开关磁阻电机系统理论与控制技术[M]. 北京: 中国电力出版社, 2010: 39-51.
Wu Hongxing.Theory and Control Technology of Switched Reluctance Motor[M]. Beijing: China Electric Power Press, 2010: 39-51.

分体式开关磁阻双转子电机设计与电磁仿真

Design and Electromagnetic Simulation of Split Switched Reluctance Dual-Rotor Motor

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 7

编辑推荐

Metrics

本文评价

[1]	王丽梅, 么红岩, 张康. 直接驱动H型平台鲁棒最优同步控制仿真研究[J]. 系统仿真学报, 2022, 34(3): 527-535.
[2]	尹星, 袁登科, 甄永成, 邵仲书, 吕相杰. 基于SVPWM的永磁同步电机DTC技术[J]. 系统仿真学报, 2019, 31(11): 2535-2542.
[3]	侯利民, 任一夫, 刘恒飞, 林栋. 基于无速度传感器的永磁同步电机滑模自抗扰控制[J]. 系统仿真学报, 2019, 31(5): 963-970.
[4]	张小平, 饶盛华, 张铸, 赵轩. 基于混沌果蝇算法的SRM多目标协同优化研究[J]. 系统仿真学报, 2018, 30(7): 2640-2647.
[5]	刘希军, 张昆仑, 刘国清. 面向舰载机电磁弹射器的双边直线感应电机研究[J]. 系统仿真学报, 2016, 28(4): 951-955.
[6]	刘希军, 张昆仑, 陈殷. 单边直线感应电机最优滑差频率控制研究[J]. 系统仿真学报, 2015, 27(4): 859-865.
[7]	罗浩源, 袁登科, 胡宗杰. 不同开关表下PMSM直接转矩控制性能仿真研究[J]. 系统仿真学报, 2018, 30(11): 4375-4386.